欢迎光临济南九创门业有限公司官网!

联系我们 收藏本站 在线留言

新闻资讯

首页>>新闻资讯>>济南车库门安装需要注意那些事项
新闻资讯
联系我们
济南九创门业有限公司

联系人:李经理

电话:15006519345

网址:www.xlmygs.com

地址:济南市天桥区北园大街372号大明家居3F-A-10

济南车库门安装需要注意那些事项

来源:http://www.jnhsjlm.com 日期:2021-12-10 发布人:guanli
我们常见的车库门就是上滑式翻版车库门。上滑式翻版车库门门板又分了很多,门板有彩钢板车库门、纯实木车库门、铝木复合车库门、铝制车库门、铜质车库门。但整体的运动方式是一样的。今天就以上滑式翻版车库门为例子,向大家介绍下上滑式翻版车库门安装都需要注意哪些事宜。
Our common garage door is the up sliding replica garage door. There are many door panels of up sliding replica garage door, including color steel plate garage door, pure solid wood garage door, aluminum wood composite garage door, aluminum garage door and copper garage door. But the overall movement is the same. Today, taking the above sliding garage door as an example, I will introduce to you what matters need to be paid attention to in the installation of down and up sliding garage door.
济南车库门的安装流程
Installation process of Jinan garage door
1、整体门板的安装
1. Installation of integral door panel
A.门板合页安装时须保证水平且垂直,固定合页的自攻螺丝松紧程度一定要适中,不螺丝打滑了需要重新稍错位置再打。
A. The door hinge must be installed horizontally and vertically. The tightness of the self tapping screws for fixing the hinge must be moderate. If the screws slip, they need to be re pressed in a slightly wrong position.
B.在门体安装调试时,需保证两端水平,门体垂直,同时注意门在上下运行时不能刮碰墙面。
B. During the installation and commissioning of the door body, it is necessary to ensure that both ends are horizontal and the door body is vertical. At the same time, it is noted that the door cannot scratch the wall when running up and down.
C.各节门板造型注意对齐,不要出现错位现象
C. Pay attention to the alignment of each door panel shape and avoid dislocation
2、导轨
2. Guide rail
A.注意左右两边导轨离门垛上下端需要一致。
A. Note that the left and right guide rails shall be consistent with the upper and lower ends of the door stack.
B.注意左右两边导轨是否平行且垂直,水平高度是否一致。如果高度不一样,左右两边导轨要根据现场选择一个合适的高度。
B. Pay attention to whether the left and right guide rails are parallel and vertical and whether the horizontal height is consistent. If the height is different, the left and right guide rails shall be selected at an appropriate height according to the site.
C.让车库门弯轨的后端比前端略高一些,大致高出3~5mm。
C. Make the rear end of the garage door bent rail slightly higher than the front end, about 3 ~ 5mm higher.
3、平衡系统
3. Balance system
A.固定扭簧的轴承支架要在同一水平面上。左右两边的轴承支架与绕线轮要与左右两边导轨和门体的距离保持一致助理对称。使得左右两边钢丝绳角度对称,不刮门体和导轨。
A. The bearing support for fixing the torsion spring shall be on the same horizontal plane. The bearing brackets and winding wheels on the left and right sides shall be consistent and symmetrical with the guide rails and door bodies on the left and right sides. The angle of the steel wire rope on the left and right sides is symmetrical without scraping the door body and guide rail.
B.扭簧需要根据各项参数计算调试松紧得当。
B. The torsion spring needs to be calculated and adjusted according to various parameters, and the tightness is appropriate.
4、电机
4. Motor
济南车库门的电机要根据现场条件选择一个合适的安装位置,其丝杆的中线和门体的中线要保持对称。电机的上升力应调试至在牵门体上升时外作用力30kg即自动停止。电机下降力调试至门体运行时外作用力15kg,即自动停止。这样保护门体和电机进行运行。
A suitable installation position shall be selected for the motor of Jinan garage door according to the site conditions, and the center line of its screw rod and the center line of the door body shall be symmetrical. The lifting force of the motor shall be adjusted to stop automatically when the external force is 30kg when the traction door body rises. When the falling force of the motor is adjusted to the external force of 15kg when the door body is running, it will stop automatically. In this way, the door body and motor are protected for operation.
安装完毕后,整体门体运行时应注意有没有明显的噪声刮碰,调试运行没有明显异常情况就算合格完工啦。
After installation, pay attention to whether there is obvious noise scraping and collision during the operation of the integral door. If there is no obvious abnormality in the commissioning operation, it will be regarded as qualified and completed.
本文的精彩内容由济南车库门提供知识提供,本网站还有很多的精彩内容,更多的内容您可以点击进入:http://www.xlmygs.com 我们有专门的客服为您解答问题
The wonderful contents of this article are provided by Jinan garage door. There are many wonderful contents on this website. You can click to enter more contents: http://www.xlmygs.com We have special customer service to answer your questions

推荐阅读/ Recommended reading

车库门常见问题 Garage door FAQs 进行一些车库门故障排除可以大大维护门的结构和功能。尽管有些问题您可能无法自行进行维修,但仍有一些

车库门电机保养知识介绍 2022-01-07
有关车库门的相关知识 2022-01-06
车库门保养你知道多少? 2021-12-24
常见到的车库门类型与特点 2021-12-23

【本站图片均由网站所有方提供,部分图片来源于网络,如无意中侵犯了某媒体或个人的知识产权,请来信或来电告之,本网站将立即删除。】

  • 济南九创门业有限公司