欢迎光临济南九创门业有限公司官网!

联系我们 收藏本站 在线留言

新闻资讯

首页>>新闻资讯>>车库门电机保养知识介绍
新闻资讯
联系我们
济南九创门业有限公司

联系人:李经理

电话:15006519345

网址:www.xlmygs.com

地址:济南市天桥区北园大街372号大明家居3F-A-10

车库门电机保养知识介绍

来源:http://www.jnhsjlm.com 日期:2022-01-07 发布人:guanli
作为电动车库门重要的组成部分,电机的地位不可或缺,没有了电机,电动车库门将无法自动开启、关闭,只能同手动车库门一样,依靠人力手动完成开启关闭动作。为了确保电机可以正常使用,在对车库门电机进行保养时,有一些要点是大家需要知道的。接下来湖北车库门厂家襄阳理想门业就来说说电机保养的相关知识。
As an important part of the electric garage door, the position of the motor is indispensable. Without the motor, the electric garage door will not be able to open and close automatically. It can only be opened and closed manually by manpower like the manual garage door. In order to ensure that the motor can be used normally, there are some key points we need to know when maintaining the garage door motor. Next, Hubei garage door manufacturer Xiangyang ideal door industry will talk about the relevant knowledge of motor maintenance.
1、车库门的日常使用环境应保持干燥,不得处于潮湿的环境中,电机的表面应保持清洁,特别是进风口不得受尘土、纤维等杂质的阻碍。
1. The daily use environment of the garage door shall be kept dry and shall not be in a humid environment. The surface of the motor shall be kept clean, especially the air inlet shall not be hindered by dust, fiber and other impurities.
2、保证车库门电机在运行过程中有良好的润滑。一般来说,车库门电机运行每5000小时左右,就要补充或更换润滑脂,若运行中发现轴承过热或润滑变质时,应及时液压或换润滑脂。更换润滑脂时,应先清旧的润滑油,并用汽油洗净轴承及轴承盖的油槽,然后将润滑脂填充在轴承内外圈之间的空腔的1/2、2/3处。
2. Ensure good lubrication of garage door motor during operation. Generally speaking, the lubricating grease of garage door motor shall be supplemented or replaced every 5000 hours. If the bearing is overheated or the lubrication is deteriorated during operation, the hydraulic pressure or lubricating grease shall be replaced in time. When replacing the grease, first clean the old lubricating oil, clean the oil groove of the bearing and bearing cover with gasoline, and then fill the grease at 1 / 2 and 2 / 3 of the cavity between the inner and outer rings of the bearing.
电动车库门
Electric garage door
3、一旦发现车库门电机运行的振动及噪声明显大时,就说明电机轴承的寿命已到达限,这时需要检查轴承的径向游隙是否达到相关数值,并及时更换的电机轴承。
3. Once it is found that the vibration and noise of the garage door motor are obviously large, it indicates that the service life of the motor bearing has reached the limit. At this time, it is necessary to check whether the radial clearance of the bearing reaches the relevant value and replace the motor bearing in time.
4、当车库门电机的热保护连续发生动作时,一定要先查明故障来自哪个方向,看电机还是超负荷或保护装置整定值太低的问题,待故障消后,才能投入正常运行中。
4. When the thermal protection of garage door motor acts continuously, be sure to find out which direction the fault comes from, and see whether the motor is overloaded or the setting value of the protection device is too low. It can be put into normal operation only after the fault is eliminated.
5、若车库门电机发生故障,要拆卸时,轴伸端或非伸端处都可以取出转子。襄阳理想门业建议大家,如果没有必要卸下风扇时,好选择从非轴伸端取出转子更为方便。若需要从定子中抽出转子时,应注意防止损坏定子的绕组或绝缘。
5. If the garage door motor fails, the rotor can be taken out at the extended end or non extended end of the shaft. Xiangyang ideal door industry suggests that if it is not necessary to remove the fan, it is more convenient to take out the rotor from the non shaft extension end. If it is necessary to extract the rotor from the stator, pay attention to prevent damage to the stator winding or insulation.
本文由济南车库门作为您提供,我们的网站是:http://www.xlmygs.com我们将以全心全意的热情为您提供服务,欢迎您的访问
This article is provided by Jinan garage door. Our website is: http://www.xlmygs.com We will serve you with wholehearted enthusiasm. Welcome to visit

推荐阅读/ Recommended reading

车库门常见问题 Garage door FAQs 进行一些车库门故障排除可以大大维护门的结构和功能。尽管有些问题您可能无法自行进行维修,但仍有一些

车库门电机保养知识介绍 2022-01-07
有关车库门的相关知识 2022-01-06
车库门保养你知道多少? 2021-12-24
常见到的车库门类型与特点 2021-12-23

【本站图片均由网站所有方提供,部分图片来源于网络,如无意中侵犯了某媒体或个人的知识产权,请来信或来电告之,本网站将立即删除。】

  • 济南九创门业有限公司